CPH24/1
CPH24/1 water-based pigment stain, cherry (ready to use)
Pigmented stain: evens out colour variation, hides wood defects, levels well and has good lightfastness. Ready-mixed stain: CFH1 binder (15–20 %) is already in it for more even application and less grain raising.
- Staining furniture in any wood species
Mix calculator
Ratio 100 : 20.0
| Component | Weigh out |
|---|---|
| CPH24/1part A | 417 g |
| waterThinner | 83.3 g |
| Total | 500 g |
Covers roughly 5.56 m² at 90 g/m².
Ask about CPH24/1
Answers are based on the CPH24/1 data and the products it mixes with.
Mixing matrix
- waterThinner% by weight: 0–20 %recommended
Normally used straight from the can.
- CPH (other /1 colours)Additive% by weight: any ratio %dealer
Tone matching.
| Role | Material | % by weight | % by volume | When |
|---|---|---|---|---|
| Thinner | water | 0–20 %recommended | — | Normally used straight from the can. |
| Additive | CPH (other /1 colours) | any ratio %dealer | — | Tone matching. |
Percentages are per 100 parts of component A.
Characteristics
- Drying · Full cure
- 4 hdealer
- Drying · Sand or stack
- 4 hdealer
- Drying · Touch-dry
- 20–30recommended
- Drying · Conditions
- 20 °C
- Lightfastness
- good (qualitative)dealer
- Binder content
- 15–20 % CFH1dealer
Colours
- CPH24 · Cherry
Application
HVLP
- Nozzle
- 1.0–1.3recommended
- Pressure · air
- inlet 1.8–2.2 (trigger pulled), cap ≤0.7recommended
- Spray viscosity
- ≈10–13 s DIN4 as diluted — do not thicken; (near water; below the DIN4 cup's valid range)recommended
- Consumption
- 80–100 g/m²dealer
- Wet film
- 80–100recommended
- Coats
- 1 (2nd light coat only to deepen tone)recommended
- Flash-off
- 10–20 before wiping/levelling; 4 h before sealerrecommended
- Recoat
- 4 h at 20 °C before primer/sealerdealer
Spray one even wet coat from 15–20 cm, fan fully open, 50 % overlap. No runs or puddles — pigment collects in pores and on end grain. Stir well before filling (the pigment settles) and strain through a 125–190 µm filter.
Conventional spray
- Nozzle
- 1.0–1.2recommended
- Pressure · air
- 2.0–3.0recommended
- Consumption
- 80–100 g/m²dealer
Fine for small batches; transfer efficiency only up to ~40 % (methods page).
Airmix (air-assisted airless)
- Nozzle
- 0.18–0.23 (tip 007–009 thou), fan 20–40°recommended
- Pressure · fluid
- 6–12recommended
- Pressure · air
- 1–2recommended
- Consumption
- 80–100 g/m²dealer
For production runs of panels/mouldings; use the smallest tip — the material is very thin.
Cloth or pad
- Consumption
- 80–100 g/m²catalog
Catalog: 'spray + wipe' — spray on, then immediately wipe with a pad/rag to even the tone and bring out the grain.
Roller
- Consumption
- 10–20 g/m²catalog
Catalog: roller-coater application 10–20 g/m² (roller lines, flat panels only).
Process and compatibility
- Substrate preparation
- Sand P150, P180dealer
- Grain raise
- Pre-wet with clean water, dry 1–2 h, denib P180–P220 before stainingrecommended
- Goes over
- bare wood
- Goes under
- HTL20 SM
- Also goes under
- PU, acrylic, PE and NC primersrecommended
- Sanding
- Do not sand the stain itself; sand the primer at P280–P320dealer
- Temperature and humidity
- 15–25 °C, RH 40–70 %, material and part ≥15 °Crecommended
- Don'ts
- Don't stain over dust or sanding scratches — the pigment will show every one
- Don't seal before 4 h at 20 °C
- Don't sand the stain coat — you'll cut through the colour on edges
- Don't let it freeze
Storage
- Shelf life
- 12 months unopenedrecommended
- Storage temperature
- +5…+30 °C, protect from frostrecommended
- Packaging
- CPH24/1: 1, 5, 25 kgdealer
Safety: Water-reducible, no organic solvents. Wear gloves; use a P2 particulate mask when spraying. No SDS found — follow general water-borne coating practice.
Mixed into
Sources
Value tags: “official”, “dealer”, “catalog”, “schedule” are Technocolor data; “workshop” is from our own datasheets; “recommended” is our engineering estimate (hover to see the reasoning).
Not covered by the sources
- solids % (not published)
- density
- lightfastness rating (only qualitative 'светостойкость')
- official TDS / SDS (none found online)
- official spray nozzle/pressure (all derived)
- shelf life (derived)
- no official t-color.ru page for CPH24/1
- exact dilution of /1 relative to concentrate